The X-43 was an unmanned experimental hypersonic aircraft with multiple planned scale variations meant to test various aspects of hypersonic flight. It was part of the X-plane series and specifically of NASA's Hyper-X program. It set several airspeed records for jet-propelled aircraft. The X-43 is the fastest aircraft on record at approximately Mach 9.2 (7,000 mph) (11,000 km/h).
A winged booster rocket with the X-43 placed on top, called a "stack", was drop launched from a larger carrier plane. After the booster rocket (a modified first stage of the Pegasus rocket) brought the stack to the target speed and altitude, it was discarded, and the X-43 flew free using its own engine, a scramjet.
The first plane in the series, the X-43A, was a single-use vehicle. Three of them were built. The first was destroyed after malfunctioning in flight; the other two have successfully flown, with the scramjet operating for approximately 10 seconds, followed by a 10-minute glide and intentional crash into the ocean.
The X-43 was part of NASA's Hyper-X program, involving the American space agency and contractors such as Boeing, Micro Craft Inc, Orbital Sciences Corporation and General Applied Science Laboratory (GASL). Micro Craft Inc. built the X-43A and GASL built its engine.
The Hyper-X Phase I was a NASA Aeronautics and Space Technology Enterprise program being conducted jointly by the Langley Research Center, Hampton, Virginia, and the Dryden Flight Research Center, Edwards, California. Langley was the lead center and is responsible for hypersonic technology development. Dryden was responsible for flight research.
Subsequent phases were not continued as the X-43 series of aircraft was replaced by the X-51.
The X-43A aircraft was a small unpiloted test vehicle measuring just over 3.7 m in length. The vehicle was a lifting body design, where the body of the aircraft provides a significant amount of lift for flight, rather than relying on wings. The aircraft weighed roughly 3,000 pounds (about 1,300 kilograms). The X-43A was designed to be fully controllable in high-speed flight, even when gliding without propulsion. However, the aircraft was not designed to land and be recovered. Test vehicles crashed into the Pacific Ocean when the test was over.
Traveling at Mach speeds produces a lot of heat due to the compression shock waves involved in supersonic drag. At high Mach speeds, heat can become so intense that metal portions of the airframe melt. The X-43A compensated for this by cycling water behind the engine cowl and sidewall leading edges, cooling those surfaces. In tests, the water circulation was activated at about Mach 3. In the future, fuel may be cycled through such areas instead, much like what is currently done in many liquid-fuel rocket nozzles and high speed aircraft such as the SR-71.
The craft was created to develop and test a supersonic-combustion ramjet, or "scramjet" engine, an engine variation where external combustion takes place within air that is flowing at supersonic speeds. The X-43A's developers designed the aircraft's airframe to be part of the propulsion system: the forebody is a part of the intake airflow, while the aft section functions as an exhaust nozzle.
The engine of the X-43A was primarily fueled with hydrogen. In the successful test, about two pounds (or roughly one kilogram) of the fuel was used. Unlike rockets, scramjet-powered vehicles do not carry oxygen on board for fueling the engine. Removing the need to carry oxygen significantly reduces the vehicle's size and weight. In the future, such lighter vehicles could take heavier payloads into space or carry payloads of the same weight much more efficiently.
Scramjets only operate at speeds in the range of Mach 4.5 (3,450 mph) or higher, so rockets or other jet engines are required to initially boost scramjet-powered aircraft to this base velocity. In the case of the X-43A, the aircraft was accelerated to high speed with a Pegasus rocket launched from a converted Boeing B-52 Stratofortress bomber. The combined X-43A and Pegasus vehicle was referred to as the "stack" by the program's team members.
The engines in the X-43A test vehicles were specifically designed for a certain speed range, only able to compress and ignite the fuel-air mixture when the incoming airflow is moving as expected. The first two X-43A aircraft were intended for flight at approximately Mach 7, while the third was designed to operate at speeds greater than Mach 9.8 (7,520 mph/12,100 km/h) at altitudes of 98,400 ft (30,000 m) or more.
NASA's first X-43A test on June 2, 2001 failed because the Pegasus booster lost control about 13 seconds after it was released from the B-52 carrier. The rocket experienced a control oscillation as it went transonic, eventually leading to the failure of the rocket's starboard elevon. This caused the rocket to deviate significantly from the planned course, so the stack was destroyed by the activation of onboard explosive charges by the Range Safety Officer as a safety precaution. An investigation into the incident stated that imprecise information about the capabilities of the rocket as well as its flight environment contributed to the accident. Several inaccuracies in data modeling for this test led to an inadequate control system for the particular Pegasus rocket used, though no single factor could ultimately be blamed for the failure.
In the second test in March 2004, the Pegasus fired successfully and released the test vehicle at an altitude of about 29,000 metres (95,000 ft). After separation, the engine's air intake was opened, the engine ignited, and the aircraft then accelerated away from the rocket reaching Mach 6.83 or 7,401 km/h (4,600 mph). Fuel was flowing to the engine for 11 seconds, a time in which the aircraft traveled more than 24 km. Following Pegasus booster separation, the vehicle experienced a small drop in speed but the scramjet engine afterward accelerated the vehicle in climbing flight. After burnout, controllers were still able to maneuver the vehicle and manipulate the flight controls for several minutes as the aircraft was slowed by air resistance as it fell into the ocean. With this flight the X-43A became the fastest free flying air-breathing aircraft in the world.
NASA flew a third version of the X-43A on November 16, 2004. The modified Pegasus rocket which was launched from a B-52 mother ship at an altitude of 13,157 meters (43,166 ft). The X-43A set a new speed record of 10,617 km/h (6,598 mph) or Mach 9.65 or Mach 9.68 at about 33,528 metres (110,000 ft) altitude  (sources differ), and further testing the ability of the vehicle to withstand the heat loads involved.
Future of the scramjet: Variants and replacement
After the X-43 tests in 2004, NASA Dryden engineers said that they expected all of their efforts to culminate in the production of a two-stage-to-orbit crewed vehicle in about 20 years. The scientists expressed much doubt that there would be a Single Stage to Orbit crewed vehicle like the National Aerospace Plane (NASP) in the foreseeable future, also known as the "Orient Express", that would take off from an ordinary airport runway.
Other X-43 vehicles were planned, but as of June 2013[update] have been suspended or cancelled. They were expected to have the same basic body design as the X-43A, though the aircraft were expected to be moderately to significantly larger in size.
The X-43B, was expected to be a full-size vehicle, incorporating a turbine-based combined cycle (TBCC) engine or a rocket-based combined cycle (RBCC) ISTAR engine. Jet turbines or rockets would initially propel the vehicle to supersonic speed. A ramjet might take over starting at Mach 2.5, with the engine converting to a scramjet configuration at approximately Mach 5.
The X-43C would have been somewhat larger than the X-43A and was expected to test the viability of hydrocarbon fuel, possibly with the HyTech engine. While most scramjet designs have used hydrogen for fuel, HyTech runs with conventional kerosene-type hydrocarbon fuels, which are more practical for support of operational vehicles. The building of a full-scale engine was planned which would use its own fuel for cooling. The engine cooling system would have acted as a chemical reactor by breaking long-chain hydrocarbons into short-chain hydrocarbons for a rapid burn.
The X-43C was indefinitely suspended in March 2004. The linked story reports the project's indefinite suspension and the appearance of Rear Admiral Craig E. Steidle before a House Space and Aeronautics subcommittee hearing on March 18, 2004. In mid-2005, the X-43C appeared to be funded through the end of the year.
The X-43D would have been almost identical to the X-43A, but expanded the speed envelope to approximately Mach 15. As of September 2007, only a feasibility study had been conducted by Donald B. Johnson of Boeing and Jeffrey S. Robinson of NASA's Langley Research Center. According to the introduction of the study, "The purpose of the X-43D is to gather high Mach flight environment and engine operability information which is difficult, if not impossible, to gather on the ground."
- In January 2006 the USAF announced the Force Application and Launch from Continental United States or FALCON scramjet reusable missile.
- In March 2006, it was announced that the Air Force Research Laboratory (AFRL) supersonic combustion ramjet "WaveRider" flight test vehicle had been designated as X-51A. The USAF Boeing X-51 was first flown on May 26, 2010, dropped from a B-52. So far, this signals the replacement and end of the X-43 series.
- Aircraft of comparable role, configuration and era
- Thompson, Elvia, Keith Henry and Leslie Williams. "Faster Than a Speeding Bullet: Guinness Recognizes NASA Scramjet." NASA. Retrieved: August 1, 2011.
- Harsha, Dr. Phillip T., Lowell C. Keel, Dr. Anthony Castrogiovanni and Robert T. Sherrill. “X-43A Vehicle Design and Manufacture.” AIAA 2005-3334. Retrieved: August 1, 2011.
- Swinerd 2010. p. 113.
- Martin, Guy. “Hypersonic Pioneer: The X-43A.” AircraftInFormation.info. Retrieved: August 16, 2012.
- Bentley 2008, p. 110.
- Bentley 2008, pp. 110–111.
- Heppenheimer, T.A. "Facing the Heat Barrier: A History of Hypersonics," p. 277. NASA, 2007.
- Scott, Jeff. "Speed of Sound Values in the Atmosphere of Earth." aerospaceweb.org, February 23, 2003.
- "Airbreathing Hypersonic Propulsion at Pratt & Whitney – Overview"
- "X-43: Scramjet Power Breaks the Hypersonic Barrier." AIAA, 2006.
- "NASA "Hyper-X" Program Demonstrates Scramjet Technologies." NASA." Retrieved: August 1, 2011.
- Morris, Jefferson. "X-43C, RS-84 Engine Among Casualties Of NASA Review." Aviation Week, March 19, 2004. Retrieved: January 9, 2010.
- "Good news travels fast." Boeing Frontiers, August 2005. Quote: "Thanks to a funding request of $25 million for NASA sponsored by U.S. Rep. Jim Talent (R-Mo.), work on the X-43C program will continue through 2005."
- "X-43D Conceptual Design and Feasibility Study." AIAA."" Retrieved: August 1, 2011.
- "Falcon." space.com. Retrieved: August 1, 2011.
|Wikimedia Commons has media related to Boeing X-43.|